Start Your Search

<< Return to list

1966-1969 Ford Service Department Technical Service Bulletins Lot

Price $59.05 $47.24 Details W: 8.5 x H: 11 x D: 1.25 Weight 2.25 lbs. Page Count 500+ Condition Used Original - Good Item Type Factory Manual Inventory Number SM-55839
Flat US shipping rate: $8.95
Flat International shipping rate: $48.95

---

Description

1966-1969 Ford Service Department Technical Service Bulletins Lot. Original.

The purpose of the Technical Service Bulletin (TSB) is to provide interested Dealer personnel with the current status of service problems.

The information covered will of necessity be incomplete in many cases and should be used with discretion.

Inquiries concerning items in the Bulletin were to be directed to one's District Service Manager.

Lot includes TSB #52, 53, 56, 58, 60 thru 73 (including 63 Supplement), 75 thru 80 (including 79 Supplement), 83 thru 95 (including 84 and 91 Supplements), 98 thru 100, 102, 105 thru 108 (including 107 Special Cortina Supplement), 110 thru 117, 120 thru 122. (There are some duplicates)

A sampling of some of the information found in this lot of Technical Service Bulletins.

Bulletin No. 52 December 2, 1966

956. Engine Stall or Hesitation on Acceleration (Supplement to Article No. 932 of November 4, 1966) (1967 Units with 4300 Design Carburetor Built Prior to Approximately January 3, 1967 - 289-4V, 390-4V Not-GT, 428-4V)
957. Valve Stem Tip Wear (1965-1966 240 CID Engines)
958. Temperature Switch Diagnosis (1965 Ford, 1966 Ford and Fairlane, 1967 Ford, Fairlane)
959. 1967 Ignition Coil Service Precaution (1967 Eight Cylinder Passenger Units)
960. Leaking or Poorly Grounded Oil Pressure Sender or Switch (All Cars and Trucks)
961. Headlamp Retention and Adjustment - Ball Spring Failures (1966 Ford - All Models)
962. Transistorized Voltage Regulator Failure (All W Series)

Bulletin No. 60 February 24, 1967

997. Oil Consumption Diagnosis Procedure (1965, 1966, and 1967 Light Trucks with 352 CID Engine)
998. Removal and Installation of Radio or Stereo Tape Player (1967 Thunderbird)
999. Speed Control and/or Vacuum Door Lock Switches Will Not Engage (1967 Thunderbirds Built Prior to January 2, 1967)
1000. Twin Post Repairs Stand (All Car and Truck Lines)
1001. Headlamp Bulb Breakage (1966-1967 Ford and Fairlane - All Models)
1002. Inoperative Accessories Due to Failed Relay Assembly (1966 1/2 and Early 1967 W Series Highway Tractor)

Bulletin No. 63 Supplement March 31, 1967

1021. Roof Outside Cover Replacement Procedure Revision

Bulletin No. 71 July 14, 1967

1113. Clutch Shudder in Reverse (1965-1967 F-100-250 Trucks Equipped with 352 CID Engines and 3 Speed Transmission)
1114. Crankcase Vent Tube Assembly (1967 363 Dorset Diesel Engine)
1115. Heater Core Replacement Vehicle with Air Conditioning (1967 Ford)
1116. Diagnosis of Hard Shift and Gear Rattle Complaints and Recommended Shift Points in MPH (1966-1967 Model F-100 - F-350 Trucks Equipped with New Process Gear or Warner 4-Speed Transmissions)
1117. Poor Appearance of Package Tray Mouldings (1967 Thunderbird - 65A and B)
1118. Service Procedure for Instrument Cluster Gauges (All 1967 Vehicles)
1119. Instrument Panel Steering Column Finish Plate Moulding (1967 Thunderbird)
1120. Instrument Cluster Removal (All 1967 Mustangs)
1121. Air Conditioner Compressor Secondary Dust Shield (All Models Equipped with Air Conditioning)
1122. Air Conditioning Compressor Drive Belt Vibration and Rumble Correction (1967 Mustang 289 CID Engine with Air Conditioning Built After March 1, 1967)
1123. Air Conditioning Insufficient Cooling and Evaporator Case Sweating (1967 Mustang Equipped with Integral Air Conditioning)
1124. Battery Carrier Cracking (1966-1967 W Models with Two 12 Volt or Four 6 Volt Batteries)
1125. Evaporator Case Condensate Leak (1967 Mustang Equipped with Integral Air Conditioning)
1126. Dealer Fabricated Tool for Bulb Removal from Convenience Lamp Sockets (All Model Years - All Car Lines - All Models)

Bulletin No. 84 Supplement January 26, 1968

1268. Turn Signal Indicator Light Operation and Problem Diagnosis (All 1968 Thunderbirds)

Bulletin No. 93 May 31, 1968

1405. Rear Band Wear (1968 Fords Equipped with FMX Automatic Transmissions)
1406. Engine Oil Fill (All 1969 Econoline and Club Wagon)
1407. Inadequate Ground Wire Size (1968 Broncos with Electric-Hydraulic Lift Kit No. C6TZ-19E537-D)
1408. Main Control 3-2 Timing Valve and Plug (All 1967 & 1968 C-6 Automatic Transmissions)
1409. Black Paint on Engine Compartment Side of Hood (1968 Falcon)
1410. Engine Harshness - 170 and 200 CID 6-Cylinder Engine with Automatic Transmission (1966 thru 1968 Falcon, Fairlane and Mustang Vehicles So Equipped)
1411. Fuel Starvation (All 1968 Passenger Cars and Trucks Equipped with Carburetor In-Line Fuel Filters)
1412. New Positive Stop Rocker Arm Stud (1968 Thunderbird)
1413. Tape on Hood (All 1967-1968 F&T Model Trucks)
1414. Difficult Access to Rear Inner Dual Tire Air Valve (1967-1968 F&P 350/400 with Dual Rear Wheels)
1415. Engine Dieseling (All 1968 Vehicles)
1416. Wheel Splash Enters Truck Cab at Cowl Side Vent (1967-1968 Light and Medium Conventional Cab Truck - Models F-100 - F750)
1417. Engine Compression Check (All Cars and Trucks)
1418. Loss of Coolant (All 1968 Vehicles)
1419. Body Lift Pump Repair Kit (W Series)
1420. Floor Side Outer Member Sealing (1966 and 1967 W Series without Optional Left Hand Side Rear Step Assembly)
1421. Revised Lubrication Periods (1968-1969 F-100/F-200 4x4 and Bronco - U-100)

Bulletin No. 108 January 31, 1969

1640. Rear Axle Lubricant Leakage (1968-1969 Extra Heavy Trucks with Eaton 42 DP Tandem Axles)
1641. Cold Air Leaks Affecting Heater Potential - N-Series (N Series Trucks)
1642. Headlining Air Leaks and/or Dust Entry (1967-1969 F-100 through F-750) (This article supersedes and cancels Article 1617)
1643. Vehicle Lean (All 1968 Heavy and Extra Heavy Trucks with Gas or Diesel Engines)
1644. W Series Radiator Tanks (All W Sereis Trucks)
1645. Number 3 Crossmember End Gussets (All 1964-1968 T and NT Tandem Trucks)
1646. Automatic Transmission Filler Tube Hole Plug (C4 and C6 Automatic Transmissions Used in 1969 Thunderbird, Lincoln, Mark III, Mustang and Cougar Vehicles Produced at Wixom or Dearborn Assembly Plants)
1647. Front End Lean to Right (1969 E 300 Bus)
1648. Parking Brake Lever with Locking Mechanism (1969 and Prior Model Econoline)
1649. Radiator Shroud (C-550 thru C-800, CT-800 Trucks)
1650. Engine Overheats Due to Engine Water Temperature Sending Unit to Engine Thermostat Interference (W Series Truck with Detroit 6-71 Engine)
1651. Tachometer Adapter Lubrication (Caterpillar V8 Diesel Equipped Trucks)

Condition: Shows some wear/age/yellowing. Rusty staples.

Out of Stock.